Salt-laden hog fuel (wood waste) is burnt in a fluidized bed boiler converted from a traveling grate boiler to generate steam for a specialty paper mill. The converted boiler has a design capacity of 156 t/h of steam from hog and actual generation has varied from 76% to 107% of the design capacity. The conversion has resulted in more stable operation, more complete combustion, less ash production, reduced boiler maintenance and lower fossil fuel consumption. Tire derived fuel (TDF) is used as a supplementary fuel. With an energy content of 31 GJ/t for TDF as compared to 8 GJ/t for wet hog, addition of 2%-5% TDF by weight increased the bed temperature by an average of 55 degrees C, stabilized and improved the combustion of low quality hog and high moisture content sludge. The impact of TDF addition was studied in detail. Stack emissions were tested and bottom and flyash samples were analyzed. Although TDF contains an average of 1.6% zinc and 9.2% steel wire by weight, addition of TDF did not affect total particulate emissions from the boiler. SO2 emissions were increased due to the high sulfur content of TDF (1.4%), while NOx emissions were reduced. A good correlation was obtained from the test results, showing that the addition of TDF resulted in a reduction in both the total formation and the stack emissions of dioxins and furans.