During the combustion of coal and other carbonaceous materials, the heterogeneous reaction of NO with the evolving char created in the combustion process is important for understanding the formation and reduction of NO. This investigation quantifies the effects of char burnout level and conditions on the kinetics of NO reduction by chars made from coals ranging in rank from lignite to low-volatile bituminous (Beulah Zap, Dietz, Utah Blind Canyon, Pittsburgh #8, and Pocahontas #3) as well as graphite and coconut char. Kinetic data were measured in a packed-bed reactor at temperatures between 723 and 1173 K. The rate constant for the NO-char reaction was found to depend upon the extent of burnout/conversion and conditions under which the char was burned out. The NO-char rate constant consistently decreases with increasing burnout when the char burnout levels are accomplished in a drop tube reactor at 1800 K and 3-5% O-2. However, the NO-char rate constant increases as char burnout increases (up to 90%) when the char burnout levels result from reacting the char with 3050 ppm of NO in a packed bed at 723-1173 K. For the latter case, the relationship of the NO-char rate constant (on the basis of moisture ash-free char mass) and char burnout is approximately linear with roughly the same upward slope between 20 and 80% burnout for all coal chars studied. The activation energy of the NO-char reaction is apparently independent of both char burnout level and burnout conditions. The CO2/CO ratio in the exhaust stream appears to correlate with the NO-char rate constant for the chars burned out at low-temperature conditions.