Biotechnology Letters, Vol.39, No.8, 1109-1120, 2017
Investigations into, and development of, a lyophilized and formulated recombinant human factor IX produced from CHO cells
Objectives To develop a recombinant human factor IX (rFIX) formulation equivalent to commercially available products in terms of cake appearance, residual moisture, proportion of soluble aggregates and activity maintenance for 3 months at 4-8 degrees C. Results NaCl and low bulking agent/cryoprotectant mass ratio had a negative impact on cake quality upon lyophilisation for a wide range of formulations tested. Particular devised formulations maintained rFIX activity after lyophilization with a similar performance when compared with the rFIX formulated using the excipients reported for a commercially available FIX formulation (Benefix). rFIX remained active after 3 months when stored at 4 degrees C, though this was not the case with samples stored at 40 degrees C. Interestingly, particular formulations had an increase in residual moisture after 3 months storage, but not above a 3% threshold. All four formulations tested were equivalent to the Benefix formulation in terms of particle size distribution and cake appearance. Conclusions Three specific formulations, consisting of surfactant polysorbate-80, sucrose or trehalose as cryoprotectant, mannitol or glycine as bulking agent, L-histidine as buffering agent, and NaCl added in the reconstitution liquid at 0.234% (w/v) were suitable for use with a CHO cell-derived recombinant FIX.