An experimental investigation on impact process of Boger drops onto solid surfaces

Samira Mandani; Mahmood Norouzi; Mohammad Mohsen Shahmardan

Korea-Australia Rheology Journal, Vol.30, No.2, 99-108, May, 2018

DOI10.1007/s13367-018-0011-0 Export Citation

An experimental investigation on impact process of Boger drops onto solid surfaces

Samira Mandani, Mahmood Norouzi^†, and Mohammad Mohsen Shahmardan

Mechanical Engineering Department, Shahrood University of Technology, Shahrood, Semnan 361 9995161, Iran

E-mail:

In this paper, the impact dynamics of Boger drops on dry solid surfaces is investigated experimentally. The effects of viscosity, surface wettability, and impact velocity on the spreading and receding behavior of the Newtonian and viscoelastic drops are studied in detail. They are impinged upon Plexiglas and glass substrates, which have hydrophilic properties, at the impact velocities 4.03 m/s and 4.22 m/s. The polyacrylamide drops spread out more widely and recede more rapidly than the glycerin drops. The impact velocity and the liquid viscosity have more influence on the spreading phase. However, the surface wettability shows only a minute effect on the spreading phase but a very significant effect on the receding phase. On the receding stage, the effect of impact velocity was only observed on the behavior of the low-viscosity drops. Therefore, when the low-viscosity drops impact on a hydrophilic substrate, the higher impact velocity, the receding velocity is increased.

Keywords:drop impact;solid surface;Boger fluid;viscosity;wettability;impact velocity

[References]

An SM, Lee SY, J. ILASS-Korea, 14(3), 131 (2009)
An SM, Lee SY, Exp. Therm. Fluid Sci., 37, 37 (2012)
An SM, Lee SY, Exp. Therm. Fluid Sci., 38, 140 (2012)
Bartolo D, Boudaoud A, Narcy G, Bonn D, Phys. Rev. Lett., 99, 174502 (2007)
Bergeron V, Bonn D, Martin JY, Vovelle L, Nature, 405, 772 (2000)
Bertola V, Exp. Fluids, 37, 653 (2004)
Bertola V, Int. J. Heat Mass Transfer., 52, 1786 (2009)
Bertola V, Colloids Surf. A: Physicochem. Eng. Asp., 363, 135 (2010)
Biole D, Bertola V, Colloids Surf. A: Physicochem. Eng. Asp., 467, 149 (2015)
Chandra S, Avedisian CT, Int. J. Heat Mass Transf., 35, 2377 (1992)
Copper-White JJ, Crooks R, Boger DV, Colloids Surf. A: Physicochem. Eng. Asp., 210, 105 (2002)
Cooper-White JJ, Crooks RC, Chockalingam K, Boger DV, Ind. Eng. Chem. Res., 41(25), 6443 (2002)
Crooks R, Boger DV, J. Rheol., 44(4), 973 (2000)
Crooks R, Cooper-Whitez J, Boger DV, Chem. Eng. Sci., 56(19), 5575 (2001)
Dong H, Carr WW, Morris JF, Rev. Sci. Instrum., 77, 085101 (2006)
Edgerton HE, Killian JR, Flash!: Seeing the Unseen by Ultra High-Speed Photography, 2nd Ed., CT Branford Co., Boston 1954.
German G, Bertola V, J. Phys. Condens. Matter, 21, 37511 (2009)
Han J, Kim C, J. Non-Newton. Fluid Mech., 202, 120 (2013)
Huang H, Nieuw Archief voor Wiskunde, 5(6), 63 (2005)
Huang X, Chen P, Lan M, Wang X, Liao G, Procedia Eng., 62, 852 (2013)
Jung S, Fluid Characterisation And Drop Impact In Inkjet Printing For Organic Semiconductor Devices, Ph.D Thesis, University of Cambridge 2011.
Jung S, Hutchings IM, Soft Matter, 8, 2686 (2012)
Jung S, Hoath SD, Hutchings IM, Microfluid. Nanofluid., 14, 163 (2013)
Luu LH, Forterre Y, J. Fluid Mech., 632, 301 (2009)
Moon JH, Lee JB, Lee SH, Mater. Trans., 54, 260 (2013)
Nigen S, Atom. Sprays, 15(1), 103 (2005)
Rafai S, Bonn D, Boudaoud A, J. Fluid Mech., 513, 77 (2004)
Rioboo R, Marengo M, Tropea C, Exp. Fluids, 33, 112 (2002)
Roisman IV, Phys. Fluids, 21, 052104 (2009)
Roisman IV, Rioboo R, Tropea C, Proc. R. Soc. London Ser. A: Math. Phys. Eng. Sci., 458, 1411 (2002)
Roux DC, Cooper-White JJ, McKinley GH, Tirtaatmadja V, Phys. Fluids, 15, S12 (2003)
Saidi A, Martin C, Magnin A, J. Non-Newton. Fluid Mech., 165(11-12), 596 (2010)
Scheller BL, Bousfield DW, AIChE J., 41(6), 1357 (1995)
Smith MI, Bertola V, Phys. Rev. Lett., 104, 154502 (2010)
Smith MI, Bertola V, Exp. Fluids, 50, 1385 (2011)
Son Y, Kim C, J. Non-Newton. Fluid Mech., 162(1-3), 78 (2009)
Son Y, Kim C, Yang DH, Alm DJ, Langmuir, 24(6), 2900 (2008)
Thoroddsen ST, Sakakibara J, Phys. Fluids, 10, 1359 (1998)
Thoroddsen ST, Etoh TG, Takehara K, Annu. Rev. Fluid Mech., 40, 257 (2008)
Van Dam DB, Clerc CL, Phys. Fluids, 16, 3403 (2004)
Versluis M, Exp. Fluids, 54, 1458 (2013)
Worthington AM, Proc. R. Soc. London, 25, 261 (1876)
Worthington AM, A Study of Splashes, Longmans, Green, and Co., London 1908.
Yang X, Chhasatia VH, Sun Y, Langmuir, 29(7), 2185 (2013)

[Referenced By]

[1] An SM, Lee SY, J. ILASS-Korea, 14(3), 131 (2009)

[2] An SM, Lee SY, Exp. Therm. Fluid Sci., 37, 37 (2012)

[3] An SM, Lee SY, Exp. Therm. Fluid Sci., 38, 140 (2012)

[4] Bartolo D, Boudaoud A, Narcy G, Bonn D, Phys. Rev. Lett., 99, 174502 (2007)

[5] Bergeron V, Bonn D, Martin JY, Vovelle L, Nature, 405, 772 (2000)

[6] Bertola V, Exp. Fluids, 37, 653 (2004)

[7] Bertola V, Int. J. Heat Mass Transfer., 52, 1786 (2009)

[8] Bertola V, Colloids Surf. A: Physicochem. Eng. Asp., 363, 135 (2010)

[9] Biole D, Bertola V, Colloids Surf. A: Physicochem. Eng. Asp., 467, 149 (2015)

[10] Chandra S, Avedisian CT, Int. J. Heat Mass Transf., 35, 2377 (1992)

[11] Copper-White JJ, Crooks R, Boger DV, Colloids Surf. A: Physicochem. Eng. Asp., 210, 105 (2002)

[12] Cooper-White JJ, Crooks RC, Chockalingam K, Boger DV, Ind. Eng. Chem. Res., 41(25), 6443 (2002)

[13] Crooks R, Boger DV, J. Rheol., 44(4), 973 (2000)

[14] Crooks R, Cooper-Whitez J, Boger DV, Chem. Eng. Sci., 56(19), 5575 (2001)

[15] Dong H, Carr WW, Morris JF, Rev. Sci. Instrum., 77, 085101 (2006)

[16] Edgerton HE, Killian JR, Flash!: Seeing the Unseen by Ultra High-Speed Photography, 2nd Ed., CT Branford Co., Boston 1954.

[17] German G, Bertola V, J. Phys. Condens. Matter, 21, 37511 (2009)

[18] Han J, Kim C, J. Non-Newton. Fluid Mech., 202, 120 (2013)

[19] Huang H, Nieuw Archief voor Wiskunde, 5(6), 63 (2005)

[20] Huang X, Chen P, Lan M, Wang X, Liao G, Procedia Eng., 62, 852 (2013)

[21] Jung S, Fluid Characterisation And Drop Impact In Inkjet Printing For Organic Semiconductor Devices, Ph.D Thesis, University of Cambridge 2011.

[22] Jung S, Hutchings IM, Soft Matter, 8, 2686 (2012)

[23] Jung S, Hoath SD, Hutchings IM, Microfluid. Nanofluid., 14, 163 (2013)

[24] Luu LH, Forterre Y, J. Fluid Mech., 632, 301 (2009)

[25] Moon JH, Lee JB, Lee SH, Mater. Trans., 54, 260 (2013)

[26] Nigen S, Atom. Sprays, 15(1), 103 (2005)

[27] Rafai S, Bonn D, Boudaoud A, J. Fluid Mech., 513, 77 (2004)

[28] Rioboo R, Marengo M, Tropea C, Exp. Fluids, 33, 112 (2002)

[29] Roisman IV, Phys. Fluids, 21, 052104 (2009)

[30] Roisman IV, Rioboo R, Tropea C, Proc. R. Soc. London Ser. A: Math. Phys. Eng. Sci., 458, 1411 (2002)

[31] Roux DC, Cooper-White JJ, McKinley GH, Tirtaatmadja V, Phys. Fluids, 15, S12 (2003)

[32] Saidi A, Martin C, Magnin A, J. Non-Newton. Fluid Mech., 165(11-12), 596 (2010)

[33] Scheller BL, Bousfield DW, AIChE J., 41(6), 1357 (1995)

[34] Smith MI, Bertola V, Phys. Rev. Lett., 104, 154502 (2010)

[35] Smith MI, Bertola V, Exp. Fluids, 50, 1385 (2011)

[36] Son Y, Kim C, J. Non-Newton. Fluid Mech., 162(1-3), 78 (2009)

[37] Son Y, Kim C, Yang DH, Alm DJ, Langmuir, 24(6), 2900 (2008)

[38] Thoroddsen ST, Sakakibara J, Phys. Fluids, 10, 1359 (1998)

[39] Thoroddsen ST, Etoh TG, Takehara K, Annu. Rev. Fluid Mech., 40, 257 (2008)

[40] Van Dam DB, Clerc CL, Phys. Fluids, 16, 3403 (2004)

[41] Versluis M, Exp. Fluids, 54, 1458 (2013)

[42] Worthington AM, Proc. R. Soc. London, 25, 261 (1876)

[43] Worthington AM, A Study of Splashes, Longmans, Green, and Co., London 1908.

[44] Yang X, Chhasatia VH, Sun Y, Langmuir, 29(7), 2185 (2013)