Research on characterization method and influencing factors of sedimentation stability of magnetorheological fluid

Yuqing Li; Yiping Luo; Ying Wang; Jiao Luo; Yameng Chen

Korea-Australia Rheology Journal, Vol.33, No.4, 309-320, November, 2021

DOI10.1007/s13367-021-0024-y Export Citation

Research on characterization method and influencing factors of sedimentation stability of magnetorheological fluid

Yuqing Li, Yiping Luo^†, Ying Wang, Jiao Luo, and Yameng Chen

School of Mechanical and Automotive Engineering, Shanghai University of Engineering Science, Shanghai 201620, China

E-mail:

The sedimentation stability of Magnetorheological fluid (MRF) is one of the research hotspots in the academic field of magnetorheological science. Excellent sedimentation stability is of great significance for the preservation and application of MRF. Given many traditional methods of characterization of sedimentation stability, this paper proposes a new method to characterize the sedimentation stability of MRF based on the change of shear yield stress during the sedimentation process of MRF. Then, the key components of the selfmade MRF shear yield stress test device were introduced in detail, and three different surfactants containing dodecyl benzoate, polyethylene glycol and oleic acid were prepared. And then used the device to test their effects on the sedimentation stability of MRF. The results showed that oleic acid has the best effect on improving the sedimentation stability. Finally, the change law of shear yield stress of MRF in the next 90 days was predicted successfully by fitting experimental data based on the least square method. By comparing the test value and fitting value of 60-75 days, the error of the best fitting result were within 3%, this showed the reliability of the predicted results.

Keywords:MRF;sedimentation stability;shear yield stress;characterization;surfactant;least square method

[References]

Abdeddaim M, Ounis A, Shrimali MK, Datta TK, Struct. Eng. Mech., 62, 197 (2017)
Changchun Z, Pengcheng Z, Lisheng L, Qingjie Z, J. Wuhan Univ. Technol.-Mat. Sci. Edit., 20, 52 (2005)
Choi HG, Cho SH, Jung YY, Int. J. Eng. Sci., 48, 1110 (2010)
Choi YT, Xie L, Wereley NM, Smart Mater. Struct., 25, 04LT01 (2016)
Christie MD, Sun S, Deng L, Ning D, Du H, Zhang S, Li W, J. Intell. Mater. Syst. Struct., 31, 263 (2020)
Cruze D, et al. The Open Civil Engineering Journal, 14, 78 2020.
Fang FF, Liu YD, Choi HJ, Seo Y, ACS Appl. Mater. Interfaces, 3, 3487 (2011)
Fang FF, Liu YD, Choi HJ, Colloids Surf. A: Physicochem. Eng. Asp., 412, 47 (2012)
Fu D, Wang DH, Xu L, Yuan G, Smart Mater. Struct., 26, 045030 (2017)
Furst EM, Gast AP, Phys. Rev. E. Stat. Phys. Plasmas Fluids Relat. Interdiscip. Topics 61, 6732 2000.
Gorodkin S, Zhuravski N, Kordonski W, Int. J. Mod. Phys. B, 16, 2745 (2002)
Gomez-Ramirez A, Lopez-Lopez MT, Gonzalez-Caballero F, Duran JDG, Rheol. Acta, 51(9), 793 (2012)
Hu W, Wereley NM, Int. J. Mod. Phys. B, 25, 979 (2011)
Hu Z, Yan H, Yang J, Wang W, Yu R, Arab. J. Sci. Eng., 39, 7355 (2014)
Iglesias GR, Lopez-Lopez MT, Delgadom AV, Duran JDG, Rev. Sci. Instrum., 82, 073906 (2011)
Ji D, Luo Y, Ren H, Wei D, Shao J, J. Nanomater., 19, 1 (2019)
Ji M, Luo Y, Ren H, Wei D, Kang L, J. Test. Eval., 47, 3676 (2019)
Jiang X, Zhao G, Lu W, Int. J. Adv. Manuf. Technol., 106, 1043 (2019)
Kim BK Yoon DS, Kim GW, Choi SB, TAn AS, Sattel T, Appl. Sci., 10, 5586 (2020)
Kynch GJ, Trans. Faraday Soc., 48, 166 (1952)
Luo Y, Ren H, Zhou F, Advances in Materials 4, 1 2015.
Prajapati H, Shahanand J, Nimkar H, Lakdawala A, Materials Today: Proceedings, 28, 40 (2020)
Renko EK, Water SA, 24, 331 (1998)
Sato T, Kum CW, Venkatesh VC, International Journal of Nanomanufacturing, 9, 431 2013.
Seo YP, Han S, Choi J, Takahara A, Choi HJ, Seo Y, Adv. Mater., 30, 170476 (2018)
Seok J, Lee SO, Jang KI, Min BK, Lee SJ, Tribol. Trans., 52, 460 (2009)
Shamieh H, Sedaghati R, J. Intell. Mater. Syst. Struct., 29, 3199 (2018)
Sharma SK, Lee J, Int. J. Struct. Stab. Dyn., 20, 205012 (2020)
Sun T, Peng X, Li J, Feng C, Int. J. Appl. Electromagn. Mech., 43, 283 (2013)
Usui H, Saeki T, Hayashi K, Tamura T, Coal. Prep., 18, 201 (1997)
Viet LQ, et al., Journal of Aerospace System Engineering, 14, 20 2020.
Wang D, Zi B, Zeng Y, Qian S, Qian J, Smart Mater. Struct., 26, 095020 (2017)
Wang N, Liu X, Sun S, Krolczyk G, Li Z, Li W, J. Magn. Magn. Mater., 501, 16643 (2020)
Wang D, Wang Y, Zi B, Cao Z, Ding H, Mech. Mach. Theory, 147, 103762 (2020)
Wanquana J, Chunlinga Z, Yurui Z, Zuyaoa C, Peiqingb Z, Chin. J. Chem. Phys., 14, 601 (2001)
Yang J, Yan H, Hu Z, Ding D, J. Magn. Magn. Mater., 417, 214 (2016)
Yang Y, Royel S, Li Y, Li J, Yoousefi AM, Gu X, Li S, Li H, Smart Mater. Struct., 29, 114006 (2020)
Zhao J, et al., Journal of Functional Materials, 48, 8092 2017.
Zhou F, A study of preparation and stability of magnetorheological fluid, Dissertation, Shanghai University of Engineering Science 2016.
Zhou C, Study on magnetorheological impedance characteristics and its sedimentation rate detection method 2019.

[1] Abdeddaim M, Ounis A, Shrimali MK, Datta TK, Struct. Eng. Mech., 62, 197 (2017)

[2] Changchun Z, Pengcheng Z, Lisheng L, Qingjie Z, J. Wuhan Univ. Technol.-Mat. Sci. Edit., 20, 52 (2005)

[3] Choi HG, Cho SH, Jung YY, Int. J. Eng. Sci., 48, 1110 (2010)

[4] Choi YT, Xie L, Wereley NM, Smart Mater. Struct., 25, 04LT01 (2016)

[5] Christie MD, Sun S, Deng L, Ning D, Du H, Zhang S, Li W, J. Intell. Mater. Syst. Struct., 31, 263 (2020)

[6] Cruze D, et al. The Open Civil Engineering Journal, 14, 78 2020.

[7] Fang FF, Liu YD, Choi HJ, Seo Y, ACS Appl. Mater. Interfaces, 3, 3487 (2011)

[8] Fang FF, Liu YD, Choi HJ, Colloids Surf. A: Physicochem. Eng. Asp., 412, 47 (2012)

[9] Fu D, Wang DH, Xu L, Yuan G, Smart Mater. Struct., 26, 045030 (2017)

[10] Furst EM, Gast AP, Phys. Rev. E. Stat. Phys. Plasmas Fluids Relat. Interdiscip. Topics 61, 6732 2000.

[11] Gorodkin S, Zhuravski N, Kordonski W, Int. J. Mod. Phys. B, 16, 2745 (2002)

[12] Gomez-Ramirez A, Lopez-Lopez MT, Gonzalez-Caballero F, Duran JDG, Rheol. Acta, 51(9), 793 (2012)

[13] Hu W, Wereley NM, Int. J. Mod. Phys. B, 25, 979 (2011)

[14] Hu Z, Yan H, Yang J, Wang W, Yu R, Arab. J. Sci. Eng., 39, 7355 (2014)

[15] Iglesias GR, Lopez-Lopez MT, Delgadom AV, Duran JDG, Rev. Sci. Instrum., 82, 073906 (2011)

[16] Ji D, Luo Y, Ren H, Wei D, Shao J, J. Nanomater., 19, 1 (2019)

[17] Ji M, Luo Y, Ren H, Wei D, Kang L, J. Test. Eval., 47, 3676 (2019)

[18] Jiang X, Zhao G, Lu W, Int. J. Adv. Manuf. Technol., 106, 1043 (2019)

[19] Kim BK Yoon DS, Kim GW, Choi SB, TAn AS, Sattel T, Appl. Sci., 10, 5586 (2020)

[20] Kynch GJ, Trans. Faraday Soc., 48, 166 (1952)

[21] Luo Y, Ren H, Zhou F, Advances in Materials 4, 1 2015.

[22] Prajapati H, Shahanand J, Nimkar H, Lakdawala A, Materials Today: Proceedings, 28, 40 (2020)

[23] Renko EK, Water SA, 24, 331 (1998)

[24] Sato T, Kum CW, Venkatesh VC, International Journal of Nanomanufacturing, 9, 431 2013.

[25] Seo YP, Han S, Choi J, Takahara A, Choi HJ, Seo Y, Adv. Mater., 30, 170476 (2018)

[26] Seok J, Lee SO, Jang KI, Min BK, Lee SJ, Tribol. Trans., 52, 460 (2009)

[27] Shamieh H, Sedaghati R, J. Intell. Mater. Syst. Struct., 29, 3199 (2018)

[28] Sharma SK, Lee J, Int. J. Struct. Stab. Dyn., 20, 205012 (2020)

[29] Sun T, Peng X, Li J, Feng C, Int. J. Appl. Electromagn. Mech., 43, 283 (2013)

[30] Usui H, Saeki T, Hayashi K, Tamura T, Coal. Prep., 18, 201 (1997)

[31] Viet LQ, et al., Journal of Aerospace System Engineering, 14, 20 2020.

[32] Wang D, Zi B, Zeng Y, Qian S, Qian J, Smart Mater. Struct., 26, 095020 (2017)

[33] Wang N, Liu X, Sun S, Krolczyk G, Li Z, Li W, J. Magn. Magn. Mater., 501, 16643 (2020)

[34] Wang D, Wang Y, Zi B, Cao Z, Ding H, Mech. Mach. Theory, 147, 103762 (2020)

[35] Wanquana J, Chunlinga Z, Yurui Z, Zuyaoa C, Peiqingb Z, Chin. J. Chem. Phys., 14, 601 (2001)

[36] Yang J, Yan H, Hu Z, Ding D, J. Magn. Magn. Mater., 417, 214 (2016)

[37] Yang Y, Royel S, Li Y, Li J, Yoousefi AM, Gu X, Li S, Li H, Smart Mater. Struct., 29, 114006 (2020)

[38] Zhao J, et al., Journal of Functional Materials, 48, 8092 2017.

[39] Zhou F, A study of preparation and stability of magnetorheological fluid, Dissertation, Shanghai University of Engineering Science 2016.

[40] Zhou C, Study on magnetorheological impedance characteristics and its sedimentation rate detection method 2019.